Comparison of the Use of NaOH and KOH Activators in the Manufacture of Activated Carbon from Cassava Peel (Manihot utilissima)

Mitha Puspitasari; Wibiana Wulan Nandari; Faizah Hadi

doi:10.31315/e.v19i2.7245

Comparison of the Use of NaOH and KOH Activators in the Manufacture of Activated Carbon from Cassava Peel (Manihot utilissima)

Mitha Puspitasari, Wibiana Wulan Nandari, Faizah Hadi

Abstract

Cassava (Manihot utilissima) is a staple food beside rice and corn for Indonesia people. Cassava peel is a waste of cassava processing agroindustries such as tapioca flour industry, fermentation industry, and staple food industry. This waste contains a fairly high carbon element of 59,31%. Cassava peel has the potential to be used as raw material for activated carbon because of its high carbon content. Activated carbon production involved some steps such as preparing raw materials, carbonization, activation, neutralization, and analysis of water content, ash, iodine number, and analysis of the pore surface area of activated carbon. Activated carbon was activated using NaOH and KOH with concentrations of 0.1; 0,2; 0,3; 0,4; and 0,5N. The results showed that activated carbon which activated with 0,4N NaOH and 0,5N KOH provided the closest parameter with SNI 06-3730-1995 standard. The use of NaOH activator can increase the surface area of activated carbon compared to KOH activator.

Keywords

activator , NaOH, KOH , activated carbon, peel, cassava

Full Text:

PDF (Bahasa Indonesia)

References

Badan Pusat Statistik, “Pertumbuhan Ekonomi Indonesia Triwulan IV-2019,” Www.Bps.Go.Id, 2020.

Badan Standardisasi Nasional, 1995, Standar Nasional Indonesia Arang Aktif Teknis. SNI 06-3730-1995. ICS 75.160.10. Jakarta.

Baek, J., Lee, H.-M., Roh, J.-S., Lee, H.-S., Kang, H.S., Kim, B.-J., 2016, Studies on preparation and applications of polymeric precursor-based activated hard carbons: I. Activation mechanism and microstructure analyses, Microporous Mesoporous Mater, Vol. 219, January:258–264.

Batu, M.S., Naes,E., Kolo, M. M., 2022, Pembuatan karbon aktif dari limbah sabut pinang asal pulau timor sebagai biosorben logam ca dan mg dalam air tanah, Jurnal Integritas Proses, Vol.11, No.1, 21-25.

González-García, P., 2018, Activated carbon from lignocellulosics precursors: A review of the synthesis methods, characterization techniques and applications, Renew. Sustain. Energy Rev. Vol. 81, 1393–1414.

Kazemi, F., Younesi, H., Ghoreyshi, A.A., Bahramifar, N., Heidari, A., 2016, Thiol-incorporated activated carbon derived from ﬁr woodsawdust as an efﬁcient adsorbent for the removal of mercury ion: Batch and ﬁxed-bed column studies, Process Saf. Environ. Prot. Met. Vol. 100, 22–35.

Kong, L., Su, M., Peng, Y., Hou, L.a., Liu, J., Li, H., Diao, Z., Shih, K., Xiong, Y., Chen, D., 2017, Producing sawdust derived activated carbon by co-calcinations with limestone for enhanced Acid Orange II adsorption, J Clean Prod, Vol168, December: 22–29

Kurniasih, T. N., 2002, Pembuatan Asam Oksalat dari Kulit Ubi Kayu Varietas Randu dengan Larutan NaOH, Laporan Penelitian Universitas Muhammadiyah Surakarta, Surakarta.

Maulinda, L., Z. A. Nasrul, and Sari,D. N., 2017, Pemanfaatan Kulit Singkong sebagai Bahan Baku Karbon Aktif,Jurnal Teknologi Kimia Unimal 4.2: 11-19.

Mutiara, T.; Fajri, R.; Nurjannah, I., 2016, Karakterisasi karbon aktif dari serbuk kayu nangka limbah industri penggergajian dan evaluasi kapasitas penyerapan dengan methylene blue number, Teknoin, 22(6), 452–460.

Pambayun, G.S., Yulianto, R.M.E, Rachimoellah.M., Putri, E.M.M, 2013, Pembuatan karbon aktif dari arang tempurung kelapa dengan aktivator zncl2 dan na2co3 sebagai adsorben untuk mengurangi kadar fenol dalam air limbah, Jurnal Teknik POMITS, Vol.2, No.1, 116-120.

Siahaan, S.; Hutapea, M.; Hasibuan, R., 2013, Penentuan kondisi optimum suhu dan waktu karbonisasi pada pembuatan arang dari sekam padi, Jurnal Teknik Kimia USU, 2(1), 26–30.

Singh, J., Bhunia, H., Basu, S., 2019, Adsorption of CO2 on KOH activated carbon adsorbents: Effect of different mass ratios, Journal of Environmental Management, Vol. 250, November:109457

Sulaiman, F., Septiani, M., Aliyasih, S., and Huda, N., 2019, International Journal of Advence Science Engineering, 9(4), 1296–1301.

Subadra, I. Setiaji, B. dan Tahir, I., 2005, Activated Carbon Production From Coconut Shell With(Nh4)Hco3 Activator As An Adsorbent In Virgin Coconut Oil Purificatio,Prosiding Seminar Nasional Dies ke 50 FMIPA, UGM,1-8.

Tran, H.N., Chao, H.-P., You, S.-J., 2018, Activated carbons from golden shower upon different chemical activation methods: Synthesis and characterizations, Adsorpt. Sci.Technol. 36, 95–113.

Utomo, S., 2014, Pengaruh waktu aktivasi dan ukuran partikel terhadap daya serap karbon aktif dari kulit singkong dengan aktivator NaOH, Seminar Sains dan Teknologi, ISSN 2407- 1846, 1-4.

Yahya, M.A., 2018, A brief review on activated carbon derived from agriculture by-product, AIP. Conf. Proc. pp. 1 – 8

DOI: https://doi.org/10.31315/e.v19i2.7245

Refbacks

There are currently no refbacks.

Article Metrics

Metrics Loading ...

_{Metrics powered by PLOS ALM}

Eksergi p-ISSN 1410-394X, e-ISSN 2460-8203, is published by "Prodi Teknik Kimia UPN Veteran Yogyakarta".

Contact Jl. SWK 104 (Lingkar Utara) Condong catur Sleman Yogyakarta

Eksergi by http://jurnal.upnyk.ac.id/index.php/eksergi/index/ is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.

Lihat Statistik Jurnal Kami

Username
Password
Remember me